This is only a preview of the September 2023 issue of Practical Electronics. You can view 0 of the 72 pages in the full issue. Articles in this series:
|
AUDIO
OUT
AUDIO OUT
L
R
By Jake Rothman
Discrete audio op amp – Part 1
+15V
2.5V
R2
1.2kΩ
R1
1.2kΩ
From
TR1/2
2.5V
IC1
NE5534
1
7
3
+ 7
2 –
8 Comp
4
2mA 2mA
13kΩ
13kΩ
V–
1 Trim
i
Non-inverting
input
*Optional
To rest of
internal
circuit
TR2 –V
+Vi TR1
Inverting
input
RE*
RE*
TR1/2
Low-noise devices
eg, 2SC2240
4mA
3+
2–
Op amp
LTP input
transistors
biased off
Alternative wiring for
using an LM318 op amp
V+
5
8
Output
6
20pF 1.2kΩ
V–
6 Output
Typically
0.4mA
4
–15V
Fig.1. Putting discrete transistors in front of an IC op amp to get lower noise. The internal input transistors are biased off by
connecting them to the negative rail. The new low-noise transistors are connected to the next stage in the IC via the compensation
pins. The LM318 (shown inset) with external input transistors was the only way to get a top-quality audio op amp in the early 1970s.
T
he simple economics of
semiconductors means that
the vast majority of modern
electronic products are based on ICs
(integrated circuits). It’s quite rare to
see circuits made from individual,
separate transistors – what are called
‘discrete’ designs. Most analogue
signal processing systems use IC op
amps, which are almost always better
than discrete versions, especially
for precision instrumentation where
the inherent advantages of transistor
parameter matching in monolithic
devices, and the resulting low DC offset
errors, are important.
Audio priorities
However, in audio systems, which are
generally AC coupled, DC offset minimisation is less important. Also, very
high frequency response is not required.
So, a reasonable question is, why pay
for a response up to 300MHz when
100kHz is plenty for audio? In fact,
50
output drive headroom, low distortion and low noise are much more
important criteria for audio. Given
this, the small production runs of
top-quality audio equipment and
the high price of professional audio
op amp chips, it is well worth investigating if discrete design for audio
offers any advantages.
First a reminder that the OP and
AD series of op amps from Texas
Instruments are typically £2.50 to
£10 each, and these single-source
specialist audio ICs are often hard to
source or become ‘obsolete’ just after
you’ve finished a design! Regular
readers of my column will know that
there is one low-cost, multi-sourced
exception to the problem of expensive,
hard-to-find audio-friendly op amps:
the NE5534/NE5532, which typically
costs under £1. To make a discrete op
amp design worth considering, this
is definitely the chip to beat. This
project will attempt to do just that.
+15V
R1
10kΩ
IC1
NE5534
1.5mA
10mA
(Adjust with
R3 and R4)
+0.75V
TR1
BC337
+
3
–
7
2
+
4
C1
10µF
6
R3
15Ω
R5
10Ω
Output
+
C2
10µF
R4
15Ω
R6
10Ω
D2
1N4148
–0.75V
TR2
BC327
R2
10kΩ
–15V
Fig.2. Boosting the output of an IC op amp
with emitter-follower transistors. This is an
effective way to get decent drive capability
from early audio op amps such as the TL071,
which is only happy with loads above 2kΩ.
Practical Electronics | September | 2023
Fig.3. Simple discrete op amp for educational use from
mitchelectronics.co.uk. Not Hi-Fi, but excellent for getting started.
Hybrid designs
I often use a hybrid approach – sticking discrete transistors on
the front end of an IC op amp for lower noise (Fig.1) or adding
transistors to the output for higher drive, as shown in Fig.2.
While this is often a useful design technique, in the end I thought
why not go the whole hog and try to make a purely discrete
design to make a proper comparison with integrated versions.
The main bottleneck with the ‘hybrid’ approach is that the
supply voltage is limited by the op amp, typically to ±18V.
In fact, with some new op amps, the voltage rating is even
less, such as the LM4562 (±17V). This is caused by process
developments shrinking the die size, and with it the maximum
voltage rating. Discrete, small-signal bipolar transistors such as
the BC556 only cost pennies (they haven’t suffered the recent
price inflation of ICs) but are conservatively rated at 65V. This
makes it possible to make a discrete audio op amp with ±24V
to ±30V rails for a lower cost than the chip equivalent. True,
this price does not factor in labour, but for hobbyists this is
much less of a priority – it’s a ‘labour of love’!
Somewhat surprisingly, with automated surface-mount assembly techniques, a discrete design can now even save money
compared to higher-end IC designs. Other advantages discrete has
compared to conventional IC fabrication are access to high-gain
PNP transistors, low-noise metal thin-film resistors, large-value
Fig.4. Sparkos Labs, the ultimate discrete op amp?
good-quality capacitors as well as ease of modification and
upgradability. These last two factors are particularly relevant
to hobbyists – a discrete design offers endless opportunities to
tinker, fiddle with and improve a basic design.
Discrete problems
That said, most discrete op amp designs I have built have
measured worse than standard chips and I have mainly only
used them for educational purposes, such as the kit in Fig.3.
It is a real testament to the NE5534 that I have found it very
challenging to produce a discrete design that is just as good.
The circuit design presented here has similar distortion levels,
(but with no high-frequency distortion rise above 10kHz), half
the noise, twice the load capacity and ±25V output.
There are plenty of kits online available for discrete op amps,
mainly designs based on the venerable Jensen 990 from the
US. While these are excellent, they are also expensive. Price
aside, a nice aspect to them is that they can be improved upon
– for example, the Samuel Groner SGA-SOA-1 upgrade. The
Automated Processes API 2520 modules are also very popular,
and I’ve built many Gar2520 kits from Classic Audio Products.
The API pinout seems to have become a de-facto standard
for discrete op amps. Fig.4 shows a discrete SMT-built audio
op amp from Sparkos Labs. The SS2590 must be one of the
highest spec audio op amps ever made – it should be, it uses 40
transistors! I tried to import some, but the distributor couldn’t
do it for one-offs. (They cost $90 each!)
The Elektor Prelude amplifier from 1983 (shown in Fig.5) and
Codd’s Wireless World October 1979 design were both excellent
discrete op amps. I suspect these designs formed the basis of
Douglas Self’s ubiquitous ‘Blameless power amplifier’. It’s well
worth reading Self’s detailed analysis of this topology in his
Wireless World articles on power amp design (1996). This twogain-stage system (see Fig.6) has formed the basis for several PE/
EPE/Silicon Chip designs, such as the Hifi Stereo Headphone
Amplifier from PE, October 2014. It’s worth pointing out that
this sort of power amp is effectively a power op amp, and it
formed an ideal basis for my design. Most specialist IC audio
op amps use a three-stage topology, which gets rather complex
to implement in discrete circuitry, although the API2520 does
it. The NE5534 for example, uses 29 transistors.
Not so discrete
Fig.5. Elektor magazine has now moved from audio to Arduino
projects. The Prelude was an excellent discrete audio op amp.
Mine lasted over 30 years.
Practical Electronics | September | 2023
The main practical problem with an all-discrete op amp design
is its parts count, with typically a dozen transistors required
to get decent performance, as shown in the initial breadboard
design in Fig.7. All these connections and complexity do
51
Total gain ≈ 100,000
Difference amplifier
input stage long-tailed
pair (LTP)
+
Input
CComp
Output stage gain = 0.96
and stage boosts output
current by a factor of 100
–
Fig.6. Basic structure of a two-gain-stage op amp with
difference amplifier, main voltage amplifier and output stage.
Note the compensation capacitor, which defines the highfrequency roll off. This has to dominate the roll off since the roll
off provided by the transistors is poorly defined.
have an impact on reliability, and I would estimate the mean
time between failure of a discrete op amp is over ten-times
worse than for an equivalent IC version. Therefore, I wouldn’t
recommend using a discrete op amp for any system-critical
application such as avionics, but elsewhere, say in a recording
studio environment, they are certainly viable, providing they
use standard commodity parts. (Interestingly, the first UK
solid-state Hi-Fi amplifier from Toby Dinsdale (1964) started
off as an avionic servo op amp.)
Another discrete-design problem is that discrete transistors
have not improved much in the last 30 years, which means
old Mullard/Philips workhorses, like the BC549 and BD139
from the 1970s are still used. After Europe gave up transistor
development, Japanese companies, particularly Toshiba and
Sanyo, continued improving their through-hole bipolar discrete
transistors until the end of the 1990s. Their new 2SA/B/C devices,
which were developed for the large Japanese Hi-Fi amplifier
industry became highly sought after. Sadly, this progress has
also stopped, and further process improvements were directed
towards ICs, giving chips a further edge.
Excellent versions of Japanese-designed transistors are still
being produced in Korea by Unisonic Technologies Co. (UTC)
with the prefix ‘KT’ rather than ‘2S’. Some of these can still
be obtained from Profusion Plc and Tayda, but these are gradually being dropped. This has led to the usual eBay situation
of exorbitant prices and fake Toshiba devices for the unwary.
Closer to home, some discrete development continued for
a while in the UK with the Ferranti ‘Zetex’ or ZTX transistor
range, which have been popular with audiophiles. These are
now made by Diodes Incorporated.
The overall small-signal transistor development plateau led
John Little from Little Labs to use surface-mount output driver
chips in his Monotor headphone amplifier (Fig.8). Unfortunately,
I can’t find out which SMD devices he used – very frustrating!
As you can tell from this somewhat extended introduction,
the discrete vs integrated debate is complicated. For home
constructors though, I firmly believe a (well-designed) discrete
op-amp-based design is still the best option for a top quality
Hi-Fi headphone, phono or microphone amp.
Fig.7. A busy breadboard – 12 transistors is about the limit for me
before jumpy connections become a problem.
same. Thus, we will have made an amplifier with a gain of
10. For this system to work predictably we have to assume
‘ideal’ op amp characteristics – ie, the open-loop gain is infinite, no current is drawn by the inputs and the output has
zero source resistance.
I’ll now work my way through each of the stages of a conventional op amp.
The difference amplifier
The fundamental architectural feature of an operational amplifier is its differential input. That is, it has two inputs called
‘non-inverting’ and ‘inverting’, where the difference between
the two is the voltage to be amplified. A differential input
means the circuit can be configured to perform many types of
operations – for example, multiplication (amplifying), summation (mixing), subtraction (input balancing) and lots of other
analogue functions or mathematical operations.
The difference amplifier is usually based on Blumlein’s
famous long-tailed pair (LTP) configuration, which he patented
in 1936. He originally used triode valves, but today the most
common arrangement is a pair of NPN bipolar transistors (or
N-channel FETs) as shown in Fig.9.
To minimise DC offset and distortion, the two devices need
to be well matched in terms of transconductance. That is, how
much collector current flows for a given base-emitter voltage
Op amp 101
Building a discrete op amp is a great way to learn about the
internal operation of all op amps and see what is really going
on under the hood. Let’s look at the internal stages and get a
feel for how they operate and some possible optimisations.
When it comes to explaining basic op amp negative feedback linear operation, I always say, ‘the output voltage steers
itself to make the voltage difference between the two input
terminals zero’. The network in the feedback path from the
output to the inverting input then dictates what the system
does. For example, if the attenuation in the feedback network
is a factor of 10, then the output will have to be 10-times
bigger than the input to keep the two input terminals the
52
Fig.8. The Little Labs Monotor headphone amplifier – a
wonderful design, but I can’t fix it due to single-sourced SMT
output chips
Practical Electronics | September | 2023
Long-tailed
pair
0.6V
+Vi
C1
1nF
TR1
BC546
+15V
TR3
BC556
R2
620Ω
1mA
1mA
TR2
BC546
–0.7V
C3
39pF
R4
220kΩ
–1.3V
Non-inverting
input
R1
13.8V
220kΩ
R3
7.5kΩ
2.7µA DC bias
current (varies)
0V
2mA
Inverting
input
C2
220µF
NP
R5
3.3kΩ
4.5mA
–15V
high input impedance, fulfilling one of the key criteria
for an ideal op amp. In audio applications, the bias
currents from bipolar transistor inputs (see R1, Fig.9)
mean that potentiometers have to be AC coupled
to prevent scratching. However, normal JFETs have
about 40-times less transconductance than bi-polar
transistors, which means twice as much distortion.
There are esoteric audio JFETs available, such as the
2SK170 and 2SJ74 which achieve high transconductance,
at a high cost. Also, there are good Toshiba SMT devices,
such as the 2SK2145. This device has its two sources
connected together and brought out on one pin, which is
fine for our LTP purposes. As an aside, it’s worth noting
that it’s difficult to process FETs at the same time as
bipolar devices on the same IC, which makes low-noise
audio FET op amps expensive. On the other hand, with
discrete op amps, you can just solder them in.
Constant-current sources and sinks
Fig.9. The Blumlein long-tailed pair (LTP), outline dotted, originally
designed to replace transformers so that much higher bandwidths
were possible. It can use bipolar transistors, FETs or the original triodes
(the ECC88 works well at 90V) for the input devices. The circuit here is
the simplest ‘op amp’ one can make. It’s open-loop gain is 3000. The
feedback resistor (R4) is completely decoupled by C2 so that the openloop gain can be measured.
+15V
+15V
TR3
BC556
Transistor
current sink
From LTP
R4
220kΩ
To LTP
4.5mA
10kΩ
TR7
BC546
4.5mA
Set I = 1/R8
4.5mA current-regulator diode +
AJ Semitec E-452-E-562
(Rapid 47-2608)
1.7V
–15V
1V
R8
220Ω
–15V
Red LED, low-current, Vf = 1.7V
L7113 SRD-D (Rapid 55-0136)
Fig.10. Adding a constant-current load (sink) to the voltage amplifier
stage TR3 bumps the gain up to 12,500. Note ‘upside-down’ PNP
arrangement. For comparative purposes, I swapped out the resistor
for a current-regulator diode before replacing that with a biased
transistor TR7.
expressed in mA/V. The current gain (Hfe) is of less importance, unless
high source resistances are used. The transistors can be hand matched
with a multimeter or analyser, such as those made by Peak Electronic
Design (see back cover!).
The best approach is to use a dual transistor, such as the SSM2210 –
popular but pricey – so not appropriate for this high-quality, low-price
design. Toshiba introduced some surface-mount audio dual-transistors
in 2001, such as the 50V HN1C01FY. We will have provision on the
PCB for these. They are available from Mouser for around 30p.
One historical detail worth mentioning is that in the 1970s, PNP
transistors were preferred over NPNs for LTP circuits since they have
a slightly lower base spreading resistance, resulting in a lower noise
level. This difference is much smaller today, so we’ll use NPN types
for our LTP since there is much more device choice.
FET inputs
Fabricating JFETs instead of bipolar transistors in LTPs has been
used in op amp IC designs. It offers the advantage of having a very
Practical Electronics | September | 2023
For audio work, the current needed through each LTP
input device generally has to be higher than 1mA for low
noise from low source impedances. (There are however
higher impedance applications, such as moving magnet
pick-up cartridges, that may need lower currents). This
means the collector load resistors (R3 and R5, Fig.9)
have to be low value, resulting in low gain. Replacing
the resistors with current sources gives the current required but with a high effective dynamic impedance,
greatly increasing gain.
Using a current source has an additional benefit of
an increased power supply rejection ratio (PSRR) since
the current remains constant with power supply fluctuations. Current regulator diodes are the simplest way
of doing it, needing no bias supply. For R&D use they
are excellent since they just fit in a standard resistor
position. However, as a carefully selected gate-source
coupled JFET, they have become rather expensive. It’s
much cheaper to use the standard transistor design.
I found replacing the tail resistor (R3) with a current
source in Fig.9 only increased the gain to 3500, but it
did make the tail current independent of supply voltage.
(With just a resistor, the current is proportional to the
supply voltage, an unwanted variable.)
The noise from the tail current source, although higher
than a resistor, is not a problem since it is common mode
– it’s applied to both LTP input transistors equally and
thus cancelled. One of the great advantages of a discrete
op amp is that bias voltages for the current sources can
be easily accessed and decoupled with large capacitors
for low noise.
Voltage amplifying stage (VAS)
The bulk of our system voltage gain is provided by the
voltage amplifying stage (VAS), which is based on a
common-emitter strapped between the two power rails,
as shown in Fig.10. The term ‘VAS’, as coined by Douglas
Self, is really a misnomer since it has a current input.
Again, a constant current load here can provide higher
gain and better DC stability. In Fig.9, replacing the collector load resistor R5 with a 4.5mA current-regulating
diode (CRD) increased the gain to 12,500 (from 3500).
Sometimes, for higher output voltage swings, a
bootstrap capacitor is used. A current source typically
drops around 1.5V, so it is worth bootstrapping it in
low voltage applications.
The load impedance on the VAS stage output is
important. If it is too low the open-loop gain will drop
and the gain advantage of the constant-current sink will
53
Compensation
Current mirror
+15V
I reflected
0.3V
0.6V
R3
300Ω
0.3V
TR4
BC556
I set
R4
300Ω
TR5*
BC556
*TR5 wired
as diode
(transdiode)
TR1
BC546
To VAS
Inverting
input
Non-inverting
input
1mA
1mA
TR2
BC546
2mA
2mA CRD
E-202-E562 (Rapid 47-2602)
(or 6.2kΩ)
–15V
Fig.11. A current mirror on the LTP equalises
the current and increases gain further to
around 150,000 (without emitter resistors).
be lost, bringing us back to the position
of just using a load resistor again. This
problem also applies to a lesser extent to
the LTP current mirror output loading. This
effect can be minimised by using a high Hfe
transistor (>450) for TR3. Unfortunately,
we need a Vce rating of at least 50V, and
most normal high-gain transistors such as
the BC559C are around 30V.
It’s all done with mirrors
A current mirror comprising TR4 and TR5
can be used to enforce the same current
through both LTP transistors, reducing
the need for close matching of TR1 and
TR2, see Fig.11. This circuit has a pushpull action, with the current on one side
reflected in the other, so the transconductance is doubled for a given current. This
and the high dynamic load results in a
gain increase of around 10 compared to a
resistive load. Putting the current mirror
into Fig.9 increased the gain to around
150,000 at 1kHz. We are now in the realms
of ‘proper’ op amps with an open-loop
gain of around 100dB. The gain does roll
off towards high frequencies due to Miller
effect in the transistors, (the magnification
of base-collector capacitance).
Of course, the current mirror can itself
be mismatched. The inclusion of emitter
resistors in the mirror (R3 and R4 in Fig.13)
reduces the effect of transistor mismatching.
A voltage drop across these resistors of 0.3V
provides sufficient negative feedback to
equalise the mirror currents. This is also
a place to insert a DC offset trimmer to set
the quiescent voltage of the op amp output
to zero. When using discrete transistors
for TR1, TR2, TR4 and TR5, this offset is
worse due to transistor mismatching, so
adjustment is often needed.
54
+15V
All negative feedback circuits
Iq = 6mA
TR3
need compensation to prevent
Input
BC556
from
LTP
TR9
(VAS)
high-frequency oscillation. This
BC546
limits the closed-loop gain to
unity at the frequency where 180°
phase shift occurs, preventing
R1
R3
70mV
6.8kΩ
12Ω
for 6mA
positive feedback. This phase+ C1
shift is a result of high-frequency
Output
10µF
10V
losses in the transistors, mainly
R4
R2*
TR8
12Ω
6.8kΩ
the slower output transistors. The
BC546
*Can be replaced
simplest way to fix this problem
with trimmer for Iq
is to set a dominant defined roll4mA
off by wiring a small NP0 ceramic
TR10
Sink
Thermal link
BC556
(TR7)
capacitor (C3) of around 22pF to
100pF across the base-collector
–15V
junction of the VAS transistor
TR3, depending on the closedFig.12. Emitter-follower output stage. In this
loop gain.
It is difficult to determine the case a fixed bias is used in conjunction with
optimum value for this com- large emitter resistors R3 and R4. Often R2
ponent. Too much, and your has a series trimmer to allow quiescent current
high-frequency distortion is adjustment. This will drive loads down to 300Ω.
higher than it needs to be. Too If lower impedance 100Ω loads are to be driven,
low, and the odd amplifier may the output transistors will have to be upgraded
oscillate in production. One ad- to ZTX651/751 and provided with heatsinks.
vantage of discrete over chips Loads below this, such as 32Ω headphones, will
is that you can optimise this need extra output transistors (see next month).
capacitor to suit your particular
transistors and layout. For this design,
of 10 enables the compensation capacitor
39pF was used for 10-times gain and
to be reduced by 10. This then presents a
82pF for unity gain. Another trick is to
higher impedance load at high frequencies
use two capacitors to get second-order
(>10kHz), reducing the possibility of the
compensation (This is not an option on
input stage overloading. This slewing
ICs because the bigger second capacitor
distortion is an issue when high output
would use too much die area.)
voltage at high frequencies is required. It
Baxandall found it useful to add an
manifests itself when a 20kHz sinewave
additional compensation feed from the
becomes a lopsided triangle wave.
output stage. He called it ‘inclusive
A problem with these emitter resistors
Miller compensation’. This did not
(R1 and R2) is that they add Johnson noise.
make much difference with a low-power
This becomes an issue where high closedop amp, possibly because the small
loop gain is required at low impedances,
output transistors did not make such
such as in a mic or moving-coil phono
a big crossover glitch. However, it does
pre-amplifier. The input signal here is
make a difference at higher powers and
low, therefore distortion is minimal, so
will therefore be included on the PCB
it’s best to leave the resistors out. With
as an option.
JFETs these resistors are not used, since
the transconductance is low and we need
all the gain available.
Emitter resistors
A low-noise upgrade for the input stage
The maximum input into a bipolar LTP
LTP transistors (TR1, TR2, TR4 and TR5)
before noticeable soft-clipping distortion
is to use the 2SA970 and its complement
occurs, is around 50mVpk-pk. (Of course,
the 2SC2240. These are rated at 120V and
the actual signal, the error voltage, is
have a noise factor of 0.5dB.
only a couple of mV in most negative
feedback situations). The way round
this is to install emitter resistors (R1 and
Output stage
R2) to provide local negative feedback.
The output stage is a voltage follower or
A good analysis of bipolar transistor
current amplifier. In most op amps this
distortion was given by WT Cocking
is a class AB push-pull emitter follower,
in Wireless World, May 1972. These
as shown in Fig.12. The VAS stage can
resistors reduce the gain by around
comfortably drive this for low powers
10x, but this can be compensated to
down to 300Ω. For higher power, extra
a degree by increasing the operating
high-current output transistors in a Darcurrent of the LTP.
lington stage could be used. This is the
This gain reduction is useful where
best option for a high power op amp,
the current mirror is used as a collector
such as a transformer or headphone
load for the LTP, since there is generally
driver. These high power output stages
too much. Reducing the gain by a factor
add another couple of output transistors,
Practical Electronics | September | 2023
and the original output transistors become
driver transistors.
Thermal stability
The output stage normally has a preset
quiescent current, set to typically 3-15mA
to reduce crossover distortion. In discrete
circuits we have the option to increase
this to 100mA to ensure class A operation
for minimum distortion. This current
will increase as the output stage heats
up, and failure due to thermal runaway
is likely unless effective heatsinks and
stabilisation is used. Normally, a Vbe-multiplier bias transistor (TR8) is thermally
coupled to track the temperature. It’s also
bypassed by a capacitor (C4) to ensure
equal drive to both output transistors.
This set-up is easier to arrange with
discrete circuits. On integrated circuits
the whole chip gets cooked. However,
in a high-power design using the CFP
output stage, only the drivers need be
coupled to the bias generator.
Protection racket
All output stages need output short-circuit protection in the form of current
R3
330Ω
R4
330Ω
DC
Offset
TR5
BC556
1mA
R9
6.8kΩ
1mA
R1
180Ω
PR2
5kΩ
R2
180Ω
R7
10kΩ
R6
2.2kΩ
TR6
BC546
R5
470Ω
+
C2
1µF
10V
6mA
R8
220Ω
+
+15V
–
Suggested
test
circuit
R14
1.5kΩ
–15V
R18
22kΩ
R11
12Ω
C5
100nF
70mV
Output
R12
12Ω
Thermal link
Discrete
R19
1kΩ*
C4
10µF TR11
10V BC556
Iq set
4.5mA
TR12
BC546
+
TR8
BC546
TR7
BC546
LED
red
low I
R13
2.7kΩ
R15
82kΩ
R16
5.6kΩ
R17
47kΩ
+
TR10
BC556
Mute
(Pull to 0V or V–)
C6
1µF
10V
V–
–6 to –25V
L1
10µH**
C10
100µF
+
Input
+
C7
4.7µF
R10
3.9kΩ
Inverting
input
V+
6 to 25V
(symmetrical)
TR9
BC546
C3
39pF (x10 gain)
82pF (unity gain)
TR2
BC546
Note: resistors and
capacitors have
been renumbered
from Fig.9 and Fig.12
Last, an unconventional approach
shown in Fig.14, which we will not
be using on the circuit’s PCB. This
design shows how audio op amps can
depart from the more conventional
design shown in Fig.13. It is possible
to make an op amp with a difference
amplifier comprising one transistor,
which can save cost if an expensive
device for TR1, such as a 2SJ74 FET is
needed. Single-ended stages have higher
even-order distortion since there isn’t
the cancellation of two curved transfer
characteristics (as with the LTP). There
is also a bad DC offset due to the Vbe
drop of the transistor and drop across
the feedback resistor, (since the full
stage current has to flow through it).
This is not a problem in single-rail audio
applications with low-value feedback
resistors. It has the significant advantage
of giving a 3dB lower noise level than
the differential pair.
TR3
BC556
TR1
BC546
Non-inverting
input
Odd-ball op amp
PR1
5kΩ
TR4
BC556
C1
220nF
impractical to provide the full protection
circuitry available to the IC designer, such
as thermal shutdown.
limiting. A dodgy lead or slipped probe is
all it takes to destroy the VAS and output
transistors. In its simplest form, this can
be high-value output emitter resistors
of a few tens of ohms or a series output
resistor. This of course raises the output
impedance and causes loss of headroom.
A better approach is to provide current
sensing on the emitter resistors or power
rails. One quirk of the circuit developed
here is that shorting out the LED voltage
reference for the current sources turns the
whole thing off. This allows it to have a
‘shutdown pin’ for protection purposes.
It also turns off if either power rail is
lost since the LED is wired between the
two rails. Using this approach, a rather
crude protection circuit has been devised
which allows 300Ω to be driven while
shutting it off below 100Ω.
The final discrete op amp circuit is
shown in Fig.13. It uses low-cost BC546/56
devices. A nice feature of discrete circuits
is that if you blow them up it’s usually
only a few cheap transistors and resistors
that are easily replaced; with an expensive chip, that’s it. However, it’s easier to
damage the discrete circuit because it’s
Output
R22
47Ω**
Output isolator
150pF*
C8
R21
22kΩ
R20
2.2kΩ
(gain set x11)
+
*RF filtering on input
**Isolation from cable capacitance
C9
100µF (non-polar preferred)
0V
Fig.13. Nearly there now, the full op amp circuit. Emitter resistors R1 and R2 have been added to the LTP, reducing the stage gain
and linearising it, making it easier to prevent HF oscillation. Also, DC offset PR1 and Iq trimmers PR2 have been added. The final
PCB will have some minor enhancements to make it more versatile. There will also be provision for feedback components for basic
non-inverting and inverting configurations, as shown in the test circuit.
Practical Electronics | September | 2023
55
Cascoding
+25V
2.2mA
C6
100nF
*R3 sets
symmetrical
clipping on
output
R3
220kΩ
+
Input
R5
2kΩ
C2
68µF
15V R2
2.2kΩ
TR3
ZTX651
R9
1kΩ
D3
100mV 1N4148
R7
1kΩ
1.3V
–25V
Set
gain
8mA
Op amp
output
R11
470Ω
C10
6.8pF
(comp)
TR7
BC546
TR2/7
Cascode 23V
R1
110kΩ
R13
120Ω
+0.7V
TR5
BC556
Inverting
input
Non-inverting
23V
input
0V
TR4
ZTX751
R6
10kΩ
TR1
BC559C
C4
100nF
R10
4.7kΩ
C9
100pF
C3
330pF
D1
1N4001
D2
1N4001
0.12mA
offset*
C1
220nF
R8
22kΩ
0.13mA
0.6mA
TR2
BC549C
R4
5.6kΩ
Audio
output
TR6
ZTX651
8mA
Bias
R12
100Ω
Iq sense
D4
2.7V
1.4V
C5
22µF
+
This unusual op amp design
also uses a cascode in the VAS
in Fig.14. This is a special technique that places a common-base
amplifier (TR7) in series with a
normal common-emitter (TR2)
to make a ‘super’ transistor from
two cheap devices. This topology
improves high-frequency response
by eliminating modulation from
the Miller effect (high frequency attenuation) and Early effect
(distortion), giving much lower
overall high-frequency distortion.
It allows a low-voltage high-gain
device to be used for the lower
transistor (TR2) and a higher-voltage general-purpose device (TR7)
for the upper transistor. It does
require a bias voltage of around
2.7V to 4.7V provided by Zener
diode D4. Cascoding can also be
used with LTPs, enabling the use
of low-voltage FETs for the input
devices. This was done on the
phono pre-amp on the Pioneer
SX-1980 amp using ±34V rails.
Cascoding could be a later upgrade
for Fig.13.
Next month, we’ll make a full
discrete through-hole op amp with
construction details and test results.
R15
22kΩ
R14
220Ω
Total current on each
power rail: 10.5mA
–25V
C7
4.7µF+
35V
Overall gain of amplifier = 6x
C8
100nF
0V
Fig.14. Single-input transistor op amp derived from a design originally developed for Avondale Audio,
who eschew LTP inputs. The VAS stage is a cascode which brings HF distortion down to 0.001%.
The Taylor configuration output stage has self-regulating quiescent current, See Audio Out, Aug 2016.
STEWART OF READING
Fluke/Philips PM3092 Oscilloscope
2+2 Channel 200MHz Delay TB,
Autoset etc – £250
LAMBDA GENESYS
LAMBDA GENESYS
IFR 2025
IFR 2948B
IFR 6843
R&S APN62
Agilent 8712ET
HP8903A/B
HP8757D
HP3325A
HP3561A
HP6032A
HP6622A
HP6624A
HP6632B
HP6644A
HP6654A
HP8341A
HP83630A
HP83624A
HP8484A
HP8560E
HP8563A
HP8566B
HP8662A
Marconi 2022E
Marconi 2024
Marconi 2030
Marconi 2023A
HP 54600B Oscilloscope
Analogue/Digital Dual Trace 100MHz
Only £75, with accessories £125
(ALL PRICES PLUS CARRIAGE & VAT)
Please check availability before ordering or calling in
PSU GEN100-15 100V 15A Boxed As New
£400
PSU GEN50-30 50V 30A
£400
Signal Generator 9kHz – 2.51GHz Opt 04/11
£900
Communication Service Monitor Opts 03/25 Avionics
POA
Microwave Systems Analyser 10MHz – 20GHz
POA
Syn Function Generator 1Hz – 260kHz
£295
RF Network Analyser 300kHz – 1300MHz
POA
Audio Analyser
£750 – £950
Scaler Network Analyser
POA
Synthesised Function Generator
£195
Dynamic Signal Analyser
£650
PSU 0-60V 0-50A 1000W
£750
PSU 0-20V 4A Twice or 0-50V 2A Twice
£350
PSU 4 Outputs
£400
PSU 0-20V 0-5A
£195
PSU 0-60V 3.5A
£400
PSU 0-60V 0-9A
£500
Synthesised Sweep Generator 10MHz – 20GHz
£2,000
Synthesised Sweeper 10MHz – 26.5 GHz
POA
Synthesised Sweeper 2 – 20GHz
POA
Power Sensor 0.01-18GHz 3nW-10µW
£75
Spectrum Analyser Synthesised 30Hz – 2.9GHz
£1,750
Spectrum Analyser Synthesised 9kHz – 22GHz
£2,250
Spectrum Analsyer 100Hz – 22GHz
£1,200
RF Generator 10kHz – 1280MHz
£750
Synthesised AM/FM Signal Generator 10kHz – 1.01GHz
£325
Synthesised Signal Generator 9kHz – 2.4GHz
£800
Synthesised Signal Generator 10kHz – 1.35GHz
£750
Signal Generator 9kHz – 1.2GHz
£700
HP/Agilent HP 34401A Digital
Multimeter 6½ Digit £325 – £375
56
17A King Street, Mortimer, near Reading, RG7 3RS
Telephone: 0118 933 1111 Fax: 0118 933 2375
USED ELECTRONIC TEST EQUIPMENT
Check website www.stewart-of-reading.co.uk
HP33120A
HP53131A
HP53131A
Audio Precision
Datron 4708
Druck DPI 515
Datron 1081
ENI 325LA
Keithley 228
Time 9818
Marconi 2305
Marconi 2440
Marconi 2945/A/B
Marconi 2955
Marconi 2955A
Marconi 2955B
Marconi 6200
Marconi 6200A
Marconi 6200B
Marconi 6960B
Tektronix TDS3052B
Tektronix TDS3032
Tektronix TDS3012
Tektronix 2430A
Tektronix 2465B
Farnell AP60/50
Farnell XA35/2T
Farnell AP100-90
Farnell LF1
Racal 1991
Racal 2101
Racal 9300
Racal 9300B
Solartron 7150/PLUS
Solatron 1253
Solartron SI 1255
Tasakago TM035-2
Thurlby PL320QMD
Thurlby TG210
Modulation Meter
£250
Counter 20GHz
£295
Communications Test Set Various Options
POA
Radio Communications Test Set
£595
Radio Communications Test Set
£725
Radio Communications Test Set
£800
Microwave Test Set
£1,500
Microwave Test Set 10MHz – 20GHz
£1,950
Microwave Test Set
£2,300
Power Meter with 6910 sensor
£295
Oscilloscope 500MHz 2.5GS/s
£1,250
Oscilloscope 300MHz 2.5GS/s
£995
Oscilloscope 2 Channel 100MHz 1.25GS/s
£450
Oscilloscope Dual Trace 150MHz 100MS/s
£350
Oscilloscope 4 Channel 400MHz
£600
PSU 0-60V 0-50A 1kW Switch Mode
£300
PSU 0-35V 0-2A Twice Digital
£75
Power Supply 100V 90A
£900
Sine/Sq Oscillator 10Hz – 1MHz
£45
Counter/Timer 160MHz 9 Digit
£150
Counter 20GHz LED
£295
True RMS Millivoltmeter 5Hz – 20MHz etc
£45
As 9300
£75
6½ Digit DMM True RMS IEEE
£65/£75
Gain Phase Analyser 1mHz – 20kHz
£600
HF Frequency Response Analyser
POA
PSU 0-35V 0-2A 2 Meters
£30
PSU 0-30V 0-2A Twice
£160 – £200
Function Generator 0.002-2MHz TTL etc Kenwood Badged
£65
Function Generator 100 microHz – 15MHz
Universal Counter 3GHz Boxed unused
Universal Counter 225MHz
SYS2712 Audio Analyser – in original box
Autocal Multifunction Standard
Pressure Calibrator/Controller
Autocal Standards Multimeter
RF Power Amplifier 250kHz – 150MHz 25W 50dB
Voltage/Current Source
DC Current & Voltage Calibrator
£350
£600
£350
POA
POA
£400
POA
POA
POA
POA
Marconi 2955B Radio
Communications Test Set – £800
Practical Electronics | September | 2023
|